FG0111E - #111E PREPARE
Material Safety Data Sheet
_______________________________________________________________________________
SECTION I - IDENTITY
_______________________________________________________________________________
#111E PREPARE
Hazardous - YES
PERMA Incorporated ------------------------------------
605 Springs Road | Health | 2 |
Bedford, MA. 01730 | Flammability | 0 |
| Reactivity | 1 |
| Personal Protection | C |
Telephone Number for Information ------------------------------------
(978)667-5161 4 = Most Hazardous
Date Prepared Emergency Phone Number
03/18/98 1-800-255-3924 or Poison Center
Prepared ByT. Pitrolffy
_______________________________________________________________________________
SECTION II - HAZARDOUS INGREDIENTS
_______________________________________________________________________________
Hazardous Components PEL TWA STEL Other Limits %
CAS Reg# mg/m3 mg/m3 mg/m3 mg/m3 (opt)
CEILING
*SULFURIC ACID #7664-93-9 1 1 3 < 5
*HYDROGEN CHLORIDE #7647-01-0 N.A. N.A. N.A. 7 < 20
OXALIC ACID # 144-62-7 1 1 2 < 3
*LISTED CHEMICAL SUBJECT TO REPORTING REQUIREMENT OF SCT.313 OF TITLE III.
_______________________________________________________________________________
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
_______________________________________________________________________________
Boiling point - 210F Specific Gravity(Water=1) - 1.04
Vapor Pressure (mm Hg) - 18.5 Melting Point - N.A.
Vapor Density (air=1) - 1.1 Evaporation Rate(Butyl Acetate=1) -0.2
Viscosity (CPS) - 5 Decomposition Temperature - NA.
Auto Ignition Temp. - NA. Solubility in Water -COMPLETE
pH - 1.5 +/-
Appearance and Odor -BLUE MILKY LIQUID WITH FRAGRANCE
_______________________________________________________________________________
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
_______________________________________________________________________________
Flash Point - N.A. Flammable Limits
LEL - N.A. UEL - N.A.
Extinguishing media - WATER
Fire Fighting Procedure - COOL CONTAINERS WITH WATER
Fire and Explosion Hazards - NON FLAMMABLE, BUT MAY REACT WITH MOST METALS
ON LONG CONTACT, WITH THE POSSIBLE EVOLUTION OF HYDROGEN
_______________________________________________________________________________
SECTION V - REACTIVITY DATA
_______________________________________________________________________________
Stability - STABLE
Conditions to Avoid - N.A.
Incompatibility - ALKALINE, CHLORINE AND CELLULOSE BASED MATERIALS
Hazardous Decomposition or Byproduct - HYDROGEN CHLORIDE GAS
Hazardous Polymerization - WILL NOT OCCUR
Conditions to Avoid - N.A.
_______________________________________________________________________________
The information herein is based on data considered accurate. However, no
warranty is expressed or implied regarding the accuracy of these data or
results to be obtained from use thereof.
Essentially similar to OSHA form # 174
_______________________________________________________________________________
SECTION VI - HEALTH HAZARD DATA
_______________________________________________________________________________
Routes of entry:
Inhalation - YES Skin - YES Ingestion - YES
Health Hazards-Acute: CAUSES SEVERE CHEMICAL BURNS TO EYES, SKIN AND MUCOUS
MEMBRANES. CHRONIC: CHEMICAL BURNS AND/OR ULCERATION OF SKIN, MAY PERMA-
NENTLY DAMAGE EYES. TARGET ORGANS: EYES, RESP. SYS., UPPER GI. TRACT, SKIN
Carcinogenicity: NO
NTP - N.A. IARC Monographs - N.A. OSHA Regulated - NO
Signs and Symptoms of Exposure - REDNESS, IRRITATION OF EYES, SKIN OR
MUCOUS MEMBRANES
Medical Conditions Aggravated - SENSITIZED SKIN
Emergency and First Aid Procedures - IMMEDIATELY WASH CONTACT AREAS (EYES)
WITH LARGE QUANTITIES OF WATER FOR 15 MINUTES.
INGESTION: DRINK LARGE AMOUNTS OF WATER OR MILK, CALL PHYSICIAN.
_______________________________________________________________________________
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
_______________________________________________________________________________
Steps to be Taken in Case Material is Released or Spilled - DIKE AND
COLLECT MATERIAL INTO PLASTIC CONTAINER. WATER RINSE AND DRAIN, FLUSH
SMALL AMOUNTS.NEUTRALIZE WITH SODA, ASH OR LIME. (BIODEGRADABLE)
Waste Disposal Method - DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
HAZARDOUS WASTE REGULATIONS; USE SANITARY LANDFILL.
EPA WASTE NO. D002
Precautions to be Taken in Handling and Storage -
USE ADEQUATE VENTILATION. DO NOT MIX WITH OTHER CHEMICALS.
AVOID PROLONGED CONTACT. KEEP FROM FREEZING AND EXCESSIVE HEAT
Other Precautions - STORE IN SECURE AREA. AVOID FOOD OR FEED CONTAMINATION.
RINSE EMPTY CONTAINERS BEFORE DISPOSAL. KEEP OUT OF REACH OF CHILDREN !
_______________________________________________________________________________
SECTION VIII - CONTROL MEASURES
_______________________________________________________________________________
Respiratory Protection - USE IN WELL VENTILATED AREA, FOLLOW DIRECTIONS,
AVOID INHALING MIST.
Ventilation Local Exhaust - RECOMMENDED
Mechanical - N.A.
Special - N.A.
Other - ASSURE FRESH AIR CIRCULATION.
Protective Gloves - REQUIRED: RUBBER, PLASTIC
Eye Protection - REQUIRED: SAFETY GLASSES, GOGGLES
Other Protection - RECOMMENDED: RUBBER OR PLASTIC APRON, EYE WASH
Work/Hygienic Practices - DO NOT EAT, DRINK OR SMOKE NEXT TO MATERIAL.
WASH HANDS/FACE AFTER WORK.
_______________________________________________________________________________
SECTION IX - TRANSPORTATION 49 CFR
_______________________________________________________________________________
Unit Cont. - 55,30,5,1 GAL.,1 QT PLASTIC Report Qty. (Lbs) - NA
OSHA - IRRITANT Labels - CORROSIVE
DOT - HAZARDOUS /X/ CORROSIVE LIQUID, PACKAGING GROUP II
UN - HAZARDOUS /X/ CORROSIVE LIQUID, PACKAGING GROUP II
DOT:Compounds, cleaning liquid(Contains Hydrochloric Acid, Phosphoric Acid)
8, NA1760, PG II UN:Corrosive liquid, acidic, inorganic, n.o.s.(Contains
Hydrochloric Acid) 8, UN3264, PG II (1 qt=limited quantity 49 CFR 173.154)
_______________________________________________________________________________
Vendor assumes no responsiblity for injury to vendee or third person proxim-
ately caused if reasonable safety procedures are not adhered to as stipulated
in the data sheet. Additionally, vendor assumes no responsibility for injury
to vendee or third persons proximately caused by abnormal use of the material
even if reasonable safety procedures are followed. Further more, vendee
assumes the risk in use of the material.
Perma Home Page
Prepare Etching and Brightning
Solution